Article

Countdown to 2010 Emissions

The infrastructure to support SCR should be in place in time for 2010 regulations.

December 2008, TruckingInfo.com - Editorial

by Steve Sturgess, Executive Editor

SHARING TOOLS        | Print Subscribe

The Diesel Exhaust Fluid Forum conference opened in early November with a number: 414. That was the number of days left before the 2010 emissions deadline, which will see trucks equipped with the next - and maybe the last - level of clean-exhaust technology.

By the time you read this, that number will be down to around 380 days - not long to put in place the infrastructure to support one of those technology solutions: selective catalytic reduction (SCR).

SCR is the add-on aftertreatment that cleans nitrogen oxides in the exhaust. A chemical reagent - urea - is used to reduce NOx to nitrogen and water vapor in a special catalyzed muffler. It requires that the vehicle carry the water solution of urea on board in sufficient quantity for the truck to get on down the road, emitting only as much NOx as the 2010 regulation allows.

Particulate matter has already been dealt with in the 2007 changes, and by now the particulate filters associated with that requirement are relatively familiar. There's no further change for PM in 2010.

So for 2010 it's all down to the NOx. SCR is one technology, favored by all engine makers with the exception of International, as you can read elsewhere in this magazine. So there's going to be a definite need for stocks of the urea solution - diesel exhaust fluid, or DEF - to be available where trucks stop and drivers pump fuel.

Hence the Diesel Exhaust Fluid Forum.

Discussion on the availability of DEF from the chemical companies, the distributors, the location and look of the containers and dispensers that will be used, and even concerns of the fleets who will be early purchasers and adopters of SCR trucks were high points of two days of discussion. And with the concerns on the table for all to see, the 400 or so days seem a perilously short time to get everything in place for Jan. 1, 2010.

Except it's going to be a while before there's much demand, as early sales of the SCR-equipped trucks will likely be very slow indeed, depending on how well any economic recovery gets in gear, and how cautious the fleets will be about the new technologies.

There's no doubt there will be DEF available. The engine makers and truck manufacturers are all committed to availability of DEF from the get-go. In fact, diesel cars will appear using SCR technology in 2009, and you'll be able to get the fluid from the car dealers like Audi, Ford, BMW and Mercedes-Benz. Though you're in for a shock if you do. Where bulk supplies of DEF are expected to be around $2.50 a gallon in 2010, if you go to a dealership bearing the three-pointed star today, they'll hit you for as much as $20 for a half gallon!

Heavy-duty users won't see anything like that. Truckstops - notably Pilot and TravelCenters of America - are committed to having DEF available. In some there will be one or two fueling lanes with DEF pumps. These will be at strategic locations on highly traveled routes. Elsewhere, you'll be able to purchase DEF in 1- and 2-gallon jugs, though likely at a significant premium over the bulk price. Fleets will also be able to get 55-gallon drums and 275-gallon "totes." These will have their own dispensing pumps.

The thing to remember is that dosing levels of DEF will be only around 2 percent. So a truck that does 120,000 miles a year at 6 mpg and thus consumes 20,000 gallons of fuel will only require 400 gallons of DEF in a year. With on-board tanks likely to be around 20-30 gallons, that means a fill-up only 15 to 20 times during the year, or about every second time the truck is fueled.

Judging from the mood at the DEFF meeting, there is a wholehearted commitment to having DEF available - at a sensible price - from all the stakeholders. It may involve something of a learning curve for truck specifiers, dispatchers and drivers alike. But the fluid will be out there.

The meeting covered a whole lot more ground and we'll be back with a full feature to talk about the issues. But having trucks stop at the side of the highway for want of a gallon of DEF will not be one of them.

Comment On This Story

Name:  
Email:  
Comment: (Maximum 2000 characters)  
Leave this field empty:
* Please note that every comment is moderated.

Newsletter

We offer e-newsletters that deliver targeted news and information for the entire fleet industry.

GotQuestions?

LUBRICANTS

The expert, Mark Betner from Citgo will answer your questions
Ask a question

Sponsored by


WHEEL ENDS SOLUTIONS

Wheel end expert Jeff Geist from STEMCO will answer your questions
Ask a question

Sponsored by

Magazine